If the issue persists, try turning the main battery pack’s switch to the “Tow” position and unplugging the negative cable for 30 minutes. Then you can reconnect the DC cord after the AC power’s blue light begins to glow. Once the red light stops flashing, wait around 30 seconds before plugging in the AC power again. In this case, you will need to remove the AC cord from the power source and the DC cord from the car to reset the charger. If the batteries are healthy, you may need to reset the charger. Your golf cart battery light may indicate less than 20% of the dash’s battery life remains. It has a really simple explanation.Īctually, there are two reasons for causing your battery light to stay on. But you don’t need to freak out about the thing. When you see your golf cart battery light is staying on all the time, it’s pretty normal to worry about the cause. Club Car Golf Cart Battery Light Stays On Why Does Club Car Golf Cart Battery Light Stays On ? Let’s jump into the article and know more about these without any further ado. The following article has covered a wide discussion about club car golf cart battery issues. When you see this warning light coming on, you need to charge the cart right away. So, the question is, why the club car golf cart battery stays on? Only battery-powered Club Car golf carts have a battery indicator that flashes when the cart’s battery is getting low. And the worry knows no bounds when the battery light won’t stop blinking. We know the frustration of dealing with battery light issues every now and then. Keep in mind that testing and troubleshooting should be done by trained and paid golf cart tech's.Club car issues can ruin your great mood for golfing on a nice sunny day. Tidewater Carts is not responsible for any malfuntions or problems that you incur directly or indirectly from folowing these procedures. This can be frustrating because you just went through all of the steps and want it to work. Remember that there is a chance the OBC has failed and the reset did not fix the problem. Once the OBC has been reset, the golf cart is ready for troubleshooting. Reconnect the negative battery terminal from the battery pack. Leave the cart like that for 5 min to cause the OBC to reset.The reverse buzzer will sound and go off in approximately 30 seconds.Lock the throttle pedal down with a second set of hands or object.Disconnect the negative battery terminal from the battery pack.However, your OBC may still be bad if everything appears to looks good visually, so you will need to reset and test.) Easily Reset the Club Car Golf Cart OBC Resetting the OBC must be performed in this order: (Note: If you have any (any) corrossion on or around the OBC or any wires leading to the OBC have corrossion or are burnt or darkly discolored due to heat - your OBC is most likely bad. You should try and manually reset the OBC to verify this isn't your problem. However, if it doesn't you might determine the controller is bad, but not so fast, there may still be a problem with the OBC. Once the controller is reinstalled, everything should work fine. Once the battery powered is removed, the OBC internals will clear any faults. If you disconnect the controller from the golf cart will cause a soft reset of the of the OBC when the battery power is removed. If the OBC does not clear the fault the controller will not power up or the solenoid will not engage. However, when the faults are cleared, the On Board Computer should reset and function properly most of the time. If the OBC detects a problem with the charging system or the drive systems it shut down. If it functions properly it controls the charging and the drive system. Club Car uses the On Board Computer or OBC to monitor and control functions of their golf carts.
0 Comments
Leave a Reply. |